Embedded Flash RoadMap 2013

Presentación del tema: "Embedded Flash RoadMap 2013"— Transcripción de la presentación:

1 Embedded Flash RoadMap 2013
Embedded Business Div. April 15, 2017

2 New Product SATA 6G Solution
SATA 3 SSD SATADOM 3 mSATA 3

3 SATA 3 SSD Solutions Controller InnoDisk ID167 (4CH) Interface
SATA III, 55nm PHY Channel 1/2/3/4 CH. x 8CE ECC 40b / 1KB Flash Supported Samsung, Micron, Toshiba NAND I/F ONFI / Toggle DRAM I/F DDRIII, 64Mx16bit PWR. Consumption Slumber: 33 mW DEVSL: 5mW F/W developed InnoDisk Sample (ES) SSD III (ES: Q1/2013) mSATA (ES: Q1/2013) Extend 2.5” SATA SSD 3MG-P 2.5” SATA SSD 3MR-P Testing Tool IOMeter 2006/2008/2010 Controller InnoDisk ID167 (4CH) Flash 4KB FW with DDR Product 2.5” SATA SSD 3MG-P (EverGreen) Performance Seq. R/W MB/s Sustain (IOPS) 64GB (4CH ) 500 / 150 80K / 1K 128GB (4CH ) 500 / 250 80K / 2K 256GB (4CH ) 550 / 400 80K / 3K

4 SATA 3 Module Solutions Controller InnoDisk ID106 (4CH) Interface
SATA 3, 55nm PHY Channel 1/2/3/4 CH. x 8CE ECC 40b / 1KB Flash Supported Samsung, Micron, Toshiba NAND I/F ONFI / Toggle DRAM I/F None PWR. Consumption Slumber: 10 mW DEVSL: 5mW F/W developed InnoDisk Sample (ES) Q1/2013 SATADOM 3ME-S mSATA 3ME-S Extend 2.5” SATA SSD 3ME-S SATA Slim 3ME-S Cfast 3ME-S CF-SATA 3ME-S

5 A solution comparable to SLC but price sweet

6 NAND Flash Evolution

7 Suitable Lifespan for your application
Base on 32G SSD, write 32Gx10 = 320G/per day. Year Notes: The iSLC lifespan is base on flash quality & innoDisk enhance algorithm.

8 TLC> E. eMLC>MLC>SLC
Flash Comparison Item SLC Single Level Cell iSLC Inno SLC mode MLC Multi Level Cell TLC Triple Level Cell Architecture SLC Flash has only two states: erased (empty) or programmed (full). Enhance iSLC, algorithm & Enhance ECC MLC Flash has four states: erased (empty), 1/3, 2/3, and programmed (full). TLC Flash has eight states: erased (empty), 1/7, 2/7, 3/7, 4/7, 5/7, 6/7 and programmed (full). Read/Write Speed Faster Fast Slow Slower Power Consumption Lower Low High Higher Endurance (P/E Cycles) 100K >30K ~ 50K 1~3K Under 1K Data Retention 10 Years 5 Years Density TLC> E. eMLC>MLC>SLC Cost $$$$+ $$+ $ $- Application 1.IPC, embedded, automation 2.Commercial application 1. IPC/Kiosk/POS system 2. Embedded System 3. Server MB 4. Replace existing 50% 2.5” SLC SSD. 1. POS, Kiosk system 2. Commercial application 1. Consumer application 2. MP3, Pen-Drive, Storage gift 10~20 times 50% off

9 Embedded Flash Product Roadmap 2013,Q1 Embedded Business Div.
April 15, 2017

10 2.5” & 1.8” SSD Series iCell Technology 2.5” Industrial (SLC) 2.5” InnoRobust (SLC)

11 iCell Technology HOST HOST Interface innoDisk ID 102 iCell technology is able to provide power after host power off. The SSD controller can write all DRAM buffer data to flash. iCell Technology can ensure all data can be written to disk without any data loss. Save all DRAM data Under 60ms iCell Technology DRAM Buffer Flash Flash Flash Flash Flash Flash Flash Flash

12 2.5” SATA SSD – Industrial Series
Available Developing Planning 2.5” SATA SSD – Industrial Series 2.5” SSD 3SE-P SATA 6Gb SMART TRIM High IOPS 2.5" SSD 3SE-P R:520/W:340MB/s, IOPS 45K 4CH/8~256GB, ID167,BGA iCell, GPIO FiD SATA 25000 SMART TRIM iCell High IOPS FiD 2.5" SATA25000(BGA) R:240/W:200MB/s 512GB FiD 2.5" SATA25000 R:240/W:200MB/s 8CH/16~128GB, 256GB (BGA) FiD SATA Plus SMART Security w/o DRAM FiD 2.5" SATA10000 Plus R:250/W:230MB/s 8CH/ 8~128GB 2.5" SSD 3SE R:520/W:340MB/s 4CH/ 8~128GB, ID106, BGA Forecast Current Q1'13 Q2'13

13 Available Developing Planning 2.5” SATA SSD – InnoRobust 2.5” SATA SSD 3SR/3MR QEraser/Destroy SEraser Write Protect MIL-STD-810F/G iCell High Capacity Q2'13 Forecast Q3'13 Current 2.5” SSD 3SR R:450/W:300MB/s, IOPS 45K 4CH/ 8~256GB, ID167, BGA 2.5” SSD 3MR R:450/W:180MB/s, IOPS 45K 4CH/ 32~256GB, ID167, TSOP InnoRobust II 2.5” SATA SSD QEraser/Destroy SEraser Write Protect MIL-STD-810F/G iCell High Capacity InnoRobust II R:170/W:140MB/s, SLC 8CH/ 8~256GB InnoRobust II R:200/W:120MB/s, MLC 8CH/ 32~512GB 2.5” SATA SSD 1SR/1MR QEraser/Destroy SEraser Write Protect MIL-STD-810F/G iCell AES-256 FIPS Level 3 2.5” SATA SSD 1SR/1MR (TSOP) ID 102 +AES bridge, R:120/W:100MB/s 8CH/ SLC: 8~256GB, MLC: 32GB~512GB

14 2.5” SATA SSD – EverGreen & InnoLite
Available Developing Planning 2.5” SATA SSD – EverGreen & InnoLite EverGreen SATA SMART, L2 Architecture Extended Lifespan 3MG-P SMART TRIM InnoLite SATA Budget Friendly Plus Q1'13 Forecast Q2'13 Current EverGreen SATA R:200/W:150MB/s, MLC 8CH/ 8~512GB 2.5” SSD 3MG R:510/W:250MB/s, MLC 4CH/ 8~256GB, ID167, TSOP EverGreen+ SATA R:200/W:150MB/s, MLC 8CH/ 7~400GB 2.5” SSD 3MG-P1 R:510/W:250MB/s, MLC 4CH/ 8~256GB, ID167, TSOP InnoLite II 2.5’’ SATA SSD R:240/W:220MB/s, MLC 8CH/ 8~512GB 2.5” SSD 3ME R:510/W:270MB/s, MLC 4CH/ 8~256GB, ID106, TSOP

15 EverGreen Architecture
General SSD Architecture L2 Architecture Data Write Data Program Program: Erase Whole Unit Program Program: Erase Whole Unit New Unit Program Program: Erase Whole Unit Data Write Data Data Write Data Program Program: Erase Whole Unit New Unit Data Write Data Data Data Data Data Erase Count +2 Erase Count +3 Erase Count +1 Erase Count +1 SSD Program Unit New Unit Write Data Program: Erase Whole Unit Disk Full: Need to Overwrite Data General SSD Architecture Program Data 1 Erase Count +1 Data 2 Data 3 Data 4 New Unit Write Data Disk Full: Need to Overwrite Data L2 Architecture Program Data 1 Data 2 Data 3 Data 4 Program: Erase Whole Unit Erase Count +1

16 New iSmart Tool

17 QEraser. SEraser. Write Protect
Available Developing Planning 2.5” PATA SSD (IDE 44 pin) FiD 2.5” ATA 9000 SMART TRIM HIGH IOPS FiD 2.5” ATA 9000 R:90/W:90MB/s, SLC 8CH/ 16~256GB FiD 2.5” ATA 8000-J SMART Security FiD 2.5" ATA 8000-J R:85/W:75MB/s 8CH/ 8~128GB Check PATA SSD sales number InnoRobust II PATA SSD QEraser. SEraser. Write Protect MIL-STD-810F/G iCell Technology InnoRobust II PATA R:90/W:90MB/s, SLC 8CH/ 16~256GB InnoLite PATA SSD SMART Security Budget Friendly InnoLite II PATA R:90/W:75MB/s, MLC 8CH/ 16~256GB Forecast Current Q1'13 Q2'13

18 InnoRobust II 1.8” SATA SSD Qeraser/Destroy SEraser
Available Developing Planning 1.8” SATA SSD FiD 1.8” SATA D150 SSD (Standard 7+15 pin) SMART Security FiD 1.8” SATA D150 SSD R:135/W:130MB/s, SLC 4CH/4~64GB 1.8” SSD 3SE R:500/W:200MB/s, SLC 4CH/4~64GB, ID106, BGA InnoLite II 1.8’’ SATA SSD (Standard 7+15 Pin) SMART Security InnoLite II 1.8” SATA SSD R:120/W:50MB/s, MLC 4CH/8~64GB 1.8” SSD 3ME R:500/W:100MB/s, MLC 4CH/8~64GB, ID106, TSOP FiD 1.8” SATA 10000 Micro SATA (Standard 7+9 pin ) SMART Security FiD 1.8” SATA 25000 R:160/W:140MB/s, SLC 8CH/ 8~64GB 1.8” SSD 3SE R:500/W:200MB/s, SLC 4CH/8~64GB, ID167, BGA 1.8” SATA SSD 2ME R:190/W:130MB/s, MLC 8CH/ 32~256GB InnoRobust II 1.8” SATA SSD Qeraser/Destroy SEraser Write Protect MIL-STD-810F InnoRobust II R:170/W:140MB/s, SLC 8CH/ 8~128GB InnoRobust II R:200/W:120MB/s, MLC 8CH/ 32GB~256GB Forecast Current Q1'13 Q2'13

19 SATA Slim, EverGreen, InnoLite SATA Slim
Available Developing Planning SATA Slim, EverGreen, InnoLite SATA Slim SATA Slim J200 SMART High IOPS SATA Slim J200 R:230/W:170MB/s SLC 8CH/ 8~64GB EverGreen SATA Slim SMART High IOPS EverGreen SATA Slim R:200/W:150MB/s, MLC 8CH/ 32~256GB SATA Slim 3MG R:500/W:100MB/s, MLC 4CH/ 32~128B, ID167, TSOP SATA Slim D150Q Smart Security SATA Slim D150Q R:135/W:130MB/s 4CH/4~64GB SATA Slim 3SE R:500 / W:200MB/s, SLC 4CH/ 8~64GB, ID106, BGA InnoLite SATA Slim II Cost-Efficient InnoLite SATA Slim D150Q R:120/W:50MB/s, MLC 4CH/ 8~64GB SATA Slim 3ME R:500/W:100MB/s, MLC 4CH/ 8~64GB, ID106, TSOP SATA Slim-M Smart, Security Micro SATA I/F SATA Slim-M R:120/W:100MB/s 4CH/2~32GB Forecast Current Q1'13 Q2'13

20 SATA DOM Series Key Specification Power Pin7 reference Circuit SATADOM RoadMap SATADOM Comparison Table

21 SATADOM Series Item SATADOM D150S SATADOM D150Q Picture
Transfer protocol SATA II Capacity 128MB~16GB 2GB~64GB Data Transfer Rate Read: 68MB/sec. Write: 62MB/sec. Read: 125MB/sec. Write: 120MB/sec. Dimension High-Profile (Vertical): 20.8*32.8*8mm Low-Profile (Vertical): 32.8*29.6*8mm High-Profile (Horizontal): 18*30.3*11.4mm Low-Profile (Horizontal): 30*20.3*11.4mm D150QV (Vertical): 25*39.4*6.5mm D150QH (Vertical): 25*39.4*9.3mm D150QV-L (Horizontal): 40*30*11.4mm Power Pin7 spec in: Intel, VIA, SuperMicro, Wistron, ASUS, MSI, Advantech, Avalue, Advansus, Protech, Lanner …

22 Intel Server board support Pin7 list
# procs segment Launching Current Board Rev Supports pin7 1S DT Rainbow Pass-EV 1H’13 G Yes, but port 4 only EN Freemont Pass shipping G No Salmon Pass G Yes, but port 1 only Jackson Pass G Yes, but port 0 only 2S Swiftcurrent Pass G Eagle Pass G Granite Pass G Black Bear Pass G Yes, port 1 Lincoln Pass G Yes, port 0 EP Canoe Pass E Jefferson Pass G JFP bridge board G Yes Washington Pass G Grizzly Pass 16 G Yes, ports 0 and 1 Grizzly Pass 24 G Iron Pass G Crown Pass G Copper Pass G King Island G 4S Lizard Head Pass G

23 SATADOM Series SLC QV SATADOM QV-L SATADOM SV SATADOM SV-L
Available Developing Planning SATADOM Series SLC All provide Vertical & Horizontal type SATADOM QV-L Zero Mechanical I/F SATADOM SV SATADOM SV-L QV SATADOM D150QV R:125/W:120MB/s, SLC 4CH/ 2GB~64GB SATADOM-MV 3SE R:500MB /W:200, SLC 2CH/ 4GB~32GB, ID106, BGA SATADOM D150QV-L R:125/W:120MB/s, SLC 4CH/ 2GB~64GB SATADOM D150SV/SH R:68/W:62 MB/s, SLC 2CH/ 4G~16GB SATADOM-SV 3SE R:200MB /W:60, SLC 2CH/ 4GB~32GB, ID107 SATADOM D150SVL R:68/W:62 MB/s, SLC 2CH/ 4G~16GB Forecast Current Q1'13 Q2'13

24 SATADOM Series MLC SATADOM QV SATADOM QVL InnoLite SATADOM QH
Available Developing Planning SATADOM Series MLC All provide Vertical & Horizontal type InnoLite SATADOM QH Budget Friendly SATADOM QVL SATADOM QV SATADOM SV SATADOM-MV 3ME R:500MB /W:100, MLC 4CH/ 4GB~128GB, ID106, TSOP Innolite SATADOM QV R:120/W:70 MB/s, MLC 4CH/ 4G~128GB Innolite SATADOM QV-L R:120/W:70 MB/s, MLC 4CH/ 4G~128GB Innolite SATADOM QH R:120/W:70 MB/s, MLC 4CH/ 4G~128GB SATADOM-SV 3ME R:100MB /W:20, SLC 1CH/ 8GB~32GB, ID107, TSOP Forecast Current Q1'13 Q2'13

25 CF & EDC Series

26 Industrial Compact Flash Card (CF Card)
Available Developing Planning Industrial Compact Flash Card (CF Card) iCF 9000 UDMA 7 iCF 8000 S.A.M.R.T Write Protect iCF 4000 S.M.A.R.T Power cycling InnoLite CF Cost-Efficient iCF 9000 (TSOP) R:95/W:90 MB/s 4CH/ 8~32GB iCF 8000 R:80/W:75MB/s 4CH/ 2~16GB iCF 4000 R:40/W:20MB/s 2CH/ 128MB~32GB iCF 4000 Plus(TSOP) R:40/W:20MB/s 2CH/ 2GB~32GB InnoLite CF R:40/W:15MB/s, MLC 2CH/ 4GB~64GB Forecast Current Q1'13 Q2'13

27 EDC Series (Industrial Embedded Disk Card)
Available Developing Planning EDC Series (Industrial Embedded Disk Card) EDC 9000 UDMA 7 Q1'13 Forecast Q2'13 Current EDC P R:95 MB/s W:90 MB/s 4CH/ 8~32GB EDC 4000 Write Protect ECC EDC 4000 R:40/W:20MB/s 2CH/ 128MB~32GB InnoLite EDC Cost-Efficient InnoLite EDC 40P/44P R:40/W:15MB/s, MLC 2CH/ 4~32GB

28 CF-SATA & CFast

29 CFAST vs. CF vs. CF-SATA Cfast D150Q CF 4000 CF SATA Capacity 2GB~32GB
Interface 7pin SATA signal + 17 power supply 50pin Compact Flash 4 pin SATA from reserved Transfer rate SATA II UDMA 0-6/PIO 0-4 Data Transfer Rate Read: 125MB/sec Write: 120MB/sec Read: 40MB/sec Write: 20MB/sec Read: 120MB/sec Write: 95MB/sec Operation Temp. 0℃~70 ℃(Standard) -40℃~+85 ℃(Industrial) Operation Voltage 3.3V 5V Dimension 36.4x42.8x3.6mm(LxWxH) 36.4x42.8x3.3mm(LxWxH) 29

30 CF-SATA Replace CF 50pins with SATA interface Support to 64GB
High-reliability: anti-shock & vibration Excellent data transfer speed Static wear-leveling algorithm Support Thermal Sensor Wear Leveling PIO 0~4 Support MDMA UDMA R: 130MB W: 120MB S.M.A.R.T SATA Signal Pin Pure IDE Mode CF_SATA Protocol 1 DGND 8 AGND 10 TX+ 11 TX– 12 13 VCC5 14 15 RX- 16 RX+　 17 38 40 GPIO (W/T, Security..)

31 CF-SATA Design in and win
ASUS(華碩), AAEON(研揚), Adlink(凌華), Avalue (安勤), Axiomtek(艾訊), PerfecTron, Lanner(立端), Portwell(瑞傳)….. Verifying & Testing Kontron, B&R, Prosoft, Rohde & Schwarz, MSI(微星), Arbor (磐儀), Fabia(函數)、ubiqconn(攸泰), FIC(大眾), ASTEC (星安科技) … 31

32 Industrial CF-SATA CF-SATA InnoLite Thermal Sensor SMART CF-SATA
Available Developing Planning Industrial CF-SATA CF-SATA Thermal Sensor SMART InnoLite CF-SATA R:120/W:95MB/s 4CH/ 8~64GB CF-SATA 3IE R:300/W:150MB/s 4CH/ 8~32GB InnoLite CF-SATA R:120/W:50MB/s 4CH/ 8~128GB CF-SATA 3ME R:300/W:100MB/s 4CH/ 8~64GB Forecast Current Q1'13 Q2'13

33 CFAST Series InnoLite CFAST CFAST D150Q CFAST 3SE CFAST D150Q (TSOP)
SMART CFAST 3SE R:500MB/W:200, SLC 4CH/ 4~64GB, ID106, BGA CFAST D150Q (TSOP) R:125/W:120MB/s 4CH/ 2~32GB InnoLite CFAST SMART / AES 128 InnoLite CFAST D150Q R:120/W:70MB/s 4CH/ 4~128GB CFAST 3ME-V R:200/W:40, MLC 2CH/ 4~64GB, ID107, TSOP Forecast Current Q1'13 Q2'13

34 miniPCIe/M2 form factor series
mSATA miniPCIeDOM miniDOM-U

35 NGFF Plan make three sockets available for Notebooks, Ultrabooks™ or Tablets A Wi-Fi centric slot A SSD cache / WWAN / Other slot SSD high performance option Support Interface: PCIe/USB/SDIO/UART/PCM/I2C/ SATA M key: PCIe x4 / SATA B key: PCIe x2 / SATA / USB / PCM / IUM / SSIC / UART-I2C A key PCIe x2 / USB / I2C / DP x4

36 NGFF SATA & PCIe ?

37 mSATA Series mSATA D150Q InnoLite II mSATA EverGreen SATA I/F
Available Developing Planning mSATA Series mSATA D150Q SATA I/F JEDEC MO-300 SLC InnoLite II mSATA MLC EverGreen Extended Lifespan Hi IOPS, MLC mSATA D150Q (BGA) R:135/W:130 MB/s 4CH/ 2~64GB mSATA mini 3ME R:200 /W:40MB/s, MLC 2CH/ 4~128GB, ID107, TSOP mSATA 3ME R:500 /W:100MB/s, MLC 4CH/ 4~128GB, ID106, TSOP InnoLite mSATA D150Q R:120W:70MB/s 4CH/ 8~128GB EverGreen mSATA R: 85/W: 35MB/s, MLC 4CH/ 8~128GB mSATA 3MG R:500 / W:100 MB/s, MLC 4CH/ 4~128GB, ID167, TSOP Forecast Current Q1'13 Q2'13

38 PCIe Series PCIeDOM Mini PCIeDOM Matador 3 W/O Driver W/O Driver
PCIe x 1 I/F High IOPS PCIe Gen 2.0 W/O Driver PCIeDOM 3MG-P-PDR R:350/W:200MB/s 4CH/ 32~128GB Mini PCIeDOM Pure PCIe I/F PCIe Gen 1.0 W/O Driver W/O Driver Mini PCIeDOM D150 (BGA) R:125/W:120MB/s 4CH/ 16GB~64GB mPCIeDOM 3ME-V R:125/W:80MB/s 4CH/ 16GB~64GB Matador 3 PCIe Gen.2 x8 Modularize design Matador 3 PCIe Gen.2 R:1200/W:1000MB/s SLC: 64~512GB MLC: 256~1TB Forecast Current Q1'13 Q2'13

39 USB & SD card series USB 3 OS Drive SD /mSD card

40 Industrial SD & Micro SD
Available Developing Planning Industrial SD & Micro SD Industrial SD Card SDHC, Class 10 ECC Write Protect SMART Micro SD SD, SDHC Card, Class 10 R:20/W:17MB/s (Max.) 1CH/ 128MB~16GB /SLC SD 3SE R:TBD/W:TBD MB/s (Max.) CH/ GB~ GB /SLC USH1 mSD 3SE-S-MDC R:TBD/W:TBD MB/s (Max.) CH/ GB~ GB /SLC USH1 Micro SD R:20/W:14MB/s (Max.) 1CH/ 1~8GB /SLC Forecast Current Q1'13 Q2'13

41 USB EDC & Nano USB USB EDC Industrial USB drive Nano USB USB I/F
Available Developing Planning USB EDC & Nano USB USB EDC USB I/F Vertical/Horizontal USB EDC R:30/W:20MB/s 1CH/ 2~8GB USB EDC 3SE R:210/W:90MB/s, Vertical 2CH/ 8~64GB Industrial USB drive A Type Industrial USB drive R:19/W:17MB/s 1CH/ 1~8GB Nano USB A type USB I/F W/T supported Nano USB 2SE-USD R:TBD/W:TBD Forecast Current Q1'13 Q2'13

42 Appendix SSD VS HDD Flash Comparison Interface Comparison Standard Interface Trend NAND Flash Evolution Various NANDs in Today’s Market 2012 NAND Flash Memory Inflection Points Wear leveling & garbage collection What TRIM Does 42

43 SSD VS HDD Comparison Chart SSD HDD Mechanism Solid NAND Flash
Magnetic rotating platters Speed (SATA II) 80-250MB/sec 65-85MB/sec Average Seek Time < 10 ms Noise None Noisy Power consumption 2W>, Low power consumption 10W, Generates more heat Weight Lightweight Heavier Endurance MTBF > 2,000,000 Hours MTBF < 700,000 Hours Temperature -40 ~ 85 0 ~ 60 Reliability Anti-shock Non-shock resistant Shock & Vibration Excellent Poor

44 New model name & P/N Model P/N 1 2 3 4 產品"種類"分類 S E - D S25 SATA SSD
S: SLC I: iSLC M: MLC E: Embedded G: Evergreen R: InnoRobust S: Server S25: SATA SSD 2.5" S18: SATA SSD 1.8" P25: PATA 2.5" P18: PATA 1.8" SATA Module CFA: CFAST CFS: CF-SATA SLM: SATA SLIM MSR: MSATA regular MSM: MSATA mini Multi Flash SATADOM SMV: SATADOM Vertical SML: SATADOM Low Profile SMH: SATADOM Horizontal Single Flash SATADOM SSV: SATADOM Vertical SSL: SATADOM Low Profile SSH: SATADOM Horizontal 3: Gen 3 2: Gen 2 SDC: SD CARD MSM: MICRO SD USD: USB drive USE: USB EDC PDR: PCIeDOM Regular PDM: mini PCIeDOM

45